Recent Bulletins
SIB 34 11 25 (2025-08-22)
BMW 530I 2025
BMW I5 2025
SERVICE BRAKES
The parking brake actuator has not been wound correctly so that it cannot be applied or released. Check Control message Parking brake failed. When parking, secure the vehicle against rolling away. Mustbe checked by the Service Partner. The vehicle is still held by the unaffected side and the transmission lock.
MC-11022100-0001.pdf
SIB 52 11 25 (2025-08-21)
BMW 840I 2020,2021,2022,2023,2024,2025
ELECTRICAL SYSTEM
If the seat ventilation is deactivated via the switch or due to parking the vehicle, the fans in the seat cushionor under the seat cushion surface are unpleasantly loud. The fans speed up loudly twice and then turn off. The functionality of the fans is not impaired. This behavior only occurs after the vehicle had been programmed to I level S18A- 25-07-520 and higher; upto, but not including S18A- 25-07-551.
MC-11022110-0001.pdf
SIB 51 04 24 (2025-08-20)
BMW X5 2023,2024
BMW X7 2024,2025
STRUCTURE: BODY
While driving on rough/uneven roads, a buzzing sound can be heard from the upper tailgate interior trim panel.
MC-11022104-0001.pdf
SIB 51 03 24 (2025-08-20)
BMW 430I 2024,2025
BMW 530I 2025
BMW 740I 2024,2025
BMW X1 2023,2024,2025
BMW X2 2023,2024,2025
BMW X3 2025
STRUCTURE: BODY
While opening any of the doors, a groaning sound is heard from the door brake. Doors open and close stiffly.
MC-11022103-0001.pdf
SIB 41 07 25 (2025-08-20)
BMW 330I 2020,2021,2022,2023,2024,2025
BMW 430I 2020,2021,2022,2023,2024
BMW M2 2020,2021,2022,2023,2024
BMW M3 2021,2022,2023,2024
BMW M4 2020,2021,2022,2023,2024,2025
STRUCTURE: BODY
While driving on a smooth and/or uneven road, a cracking sound is heard from the rear wheel arch area (highlighted in orange) on either the right or left side.
MC-11022101-0001.pdf
SIB 41 12 25 (2025-08-20)
BMW X2 2024,2025
STRUCTURE: BODY
A groaning noise is heard from the tailgate when driving on rough roads.
MC-11022102-0001.pdf
SIB 51 11 25 (2025-08-20)
BMW 530I 2025
BMW M5 2025
BMW X3 2025
STRUCTURE: BODY
When pulling on the hood (highlighted inorange in the top photo) release lever (highlighted in orange in the bottomphoto; drivers footwell shown ) , there is a noticeable lack of cable tension; and the hood will not unlock.
MC-11022105-0001.pdf
SIB 51 12 25 (2025-08-20)
BMW X2 2025
STRUCTURE: BODY
A groaning noise is heard from the tailgate when driving on rough roads.
MC-11022106-0001.pdf
SIB 63 05 25 (2025-08-20)
BMW X3 2025
EXTERIOR LIGHTING
On G45 vehicles built with option codes 552 (Full LED Lights with Cornering Lights), or 3MF (M Shadowline Lights), the headlights height setting might not be adjusted correctly.
MC-11022111-0001.pdf
SIB 52 09 20 (2025-08-19)
BMW ALPINA XB7 2022,2023
BMW B7 ALPINA 2021
BMW X7 2019,2020,2021,2022,2023,2024
(plus 1 other model)
ELECTRICAL SYSTEM
Various concerns about the third row of seats (3SR): 1. Head restraint (aka headrest), on one or both sides, cannot be folded down. 2. Third-row seating, on one or both sides, cannot be folded down. 3. Noise from third-row seat backrest when the vehicle goes over bumps.
MC-11022107-0001.pdf
SIB 63 10 23 (2025-08-19)
BMW 530I 2004,2024,2025
BMW 740I 2024,2025
BMW X1 2022,2023,2024,2025
BMW X2 2024,2025
BMW X3 2025
EXTERIOR LIGHTING
Condensation is present in the inner surface in one or both (inner and/or outer) taillamps.
MC-11022112-0001.pdf
SIB 52 10 25 (2025-08-19)
BMW X7 2024
SEATS
The electric actuator for the third row (3SR) seat changed design and part number, and is used in productionvehicles as of March 28, 2025. There are two such actuators at this seat row, one for the left seating position; and one for the right.
MC-11022109-0001.pdf
SIB 84 05 25 (2025-08-13)
BMW 430I 2023,2024,2025
BMW IX 2023,2024,2025
ELECTRICAL SYSTEM
SITUATION After the telematics module (TCB4) has been replaced, the replacement part control unit is not accepted byISTA.
MC-11022119-0001.pdf
SIB 65 10 25 (2025-08-12)
BMW X1 2024,2025
BMW X2 2024,2025
BMW X3 2025
ELECTRICAL SYSTEM
In certain situations, a mobile device with Android operating systems (Google, Samsung, etc.) may not be able to connect to the vehicle OR the Android phone may not be able to connect via Android Auto.
MC-11022114-0001.pdf
SIB 64 05 25 (2025-08-11)
BMW X3 2025
STRUCTURE: BODY
1-Customer states that the output air from one of the vehicle vent assemblies doesnt match the desired temperature, will change temperature opposite of climate settings. 2-Customer states that the output air from one of the vehicle vent assemblies doesnt match the desired temperature, nor change from Hot/Cold.
MC-11022113-0001.pdf
SIB 11 05 25 (2025-08-11)
BMW 740I 2025
BMW M5 2025
BMW X5 2025
BMW X6 2025
BMW X7 2025
ENGINE
DELIVERY STOP: OIL PAN TOP SCREW CONNECTION
MC-11021167-0001.pdf
SIB 32 01 23 (2025-08-08)
BMW 230I 2023,2024
BMW 330E 2021,2022,2023
BMW 330I 2019,2020,2021,2022,2023,2024
BMW 430I 2021,2022,2023,2024
BMW ALPINA XB7 2022,2023
BMW B7 ALPINA 2021
BMW I4 2022,2023
BMW M2 2024
BMW M3 2021,2022,2023,2024
BMW M340I 2020,2021,2022,2023
BMW M4 2021,2022,2023,2024
BMW M4 GT4 2023
BMW M440I 2021,2022
BMW X5 2019,2020,2021,2022,2023,2024
BMW X6 2020,2021,2022,2024
BMW X6 M 2020
BMW X7 2019,2020,2021,2022,2023,2024
BMW XM 2024
BMW Z4 2019,2020,2021,2022,2023
STEERING
When turning the steering wheel while stationary or when driving on uneven roads; cracking, creaking, or knocking noises may be heard.
MC-11021817-0001.pdf
SIB 65 18 25 (2025-08-08)
BMW IX 2022
BMW X1 2022,2024
ELECTRICAL SYSTEM
When the alarm system is activated and doors are locked, within a short period the doors will unlock, and a double beep acoustic confirmation is heard from vehicle.
MC-11021819-0001.pdf
SIB 33 01 25 (2025-08-07)
BMW 230I 2022,2023,2024,2025
SUSPENSION
Rattling noises heard from the area of the luggage compartment when driving over a rough road surface.
MC-11021818-0001.pdf
SIB 11 04 25 (2025-08-04)
BMW X5 2025
BMW X6 2025
BMW X7 2025
ENGINE
Due to an assembly error the upper oil pan screws may not have been torqued correctly.
MC-11021813-0001.pdf
SIB 11 06 25 (2025-08-04)
BMW 740I 2024
BMW X5 2024
BMW X7 2024
ENGINE
Due to an assembly error, the oil pump screws may not have been torqued correctly.
MC-11021816-0001.pdf
SIB 61 20 24 (2025-07-30)
BMW 740I 2022,2023
BMW I7 2023
ELECTRICAL SYSTEM
In the event of a voltage drop, comfort functions of the BMW interaction bar may fail and not respond.
MC-11021111-0001.pdf
SIB 64 04 25 (2025-07-30)
BMW 530I 2025
BMW 740I 2025
BMW M5 2025
ELECTRICAL SYSTEM
After performing a cabin air filter replacement maintenance service task, or after a similar repair thatrequired the removal and installation of the filters housing cover; the following air flap and/or air temperaturesensor faults are stored in the BCP: 80114D – Stepper motor: Unexpected error in Driving Cycle 801168 – Temperature sensor ventilation left or ventilation: short to ground 80116A – Temperature sensor ventilation right: short to ground 80116B – Temperature sensor ventilation right: short to plus or open circuit 80116C – Temperature sensor footwell left or footwell: short to ground 80116D – Temperature sensor footwell left or footwell: short to plus or open circuit 80116E – Temperature sensor footwell right: short to ground 80116F – Temperature sensor footwell right: short to plus or open circuit 80435B – Stepper motors: short-circuit by mass
MC-11021112-0001.pdf
SIB 34 09 25 (2025-07-30)
BMW 330I 2024
BMW 430I 2024
BMW M2 2024
BMW M3 2024
BMW M4 2024
SERVICE BRAKES
There may be an internal leakage in the brake fluid expansion tank (aka brake fluid reservoir). In the rare case of a leak, the filling level sensor might malfunction over a relatively long period of time.
MC-11021109-0001.pdf
SIB 41 06 25 (2025-07-30)
BMW M5 2025
STRUCTURE: BODY
BMW AG has issued a Delivery Stop(effective July 11, 2025) on certain Model Year2025 – 2026 BMW vehicles that were produced between March 24, 2025, and April16, 2025. The heat insulator (highlighted in orange) for the bulkhead was not installed. Thermal overload of the components located in the area cannot be ruled out.
MC-11021110-0001.pdf
SIB 06 42 25 (2025-07-29)
BMW X7 2024
STRUCTURE: BODY
Bowden Cable Outer Return
MC-11021128-0001.pdf
SIB 06 41 25 (2025-07-28)
BMW 330I 2024
BMW 430I 2024
BMW 530I 2024
BMW 740I 2024
BMW X3 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
UNKNOWN OR OTHER
Seal Return
MC-11021123-0001.pdf
SIB 66 10 25 (2025-07-25)
BMW IX 2025
LANE DEPARTURE: ASSIST
The lane steering assistance feature will not activate; or deactivation occurs prematurely while activated.The FRSF front radar may also have an additional fault code stored- 7E01AA FRSF lack of visibility .
MC-11020947-0001.pdf
SIB 06 40 25 (2025-07-25)
BMW IX 2024
SUSPENSION
RIGHT BALL JOINT RETURN
MC-11021121-0001.pdf
SIB 06 39 25 (2025-07-23)
BMW 330I 2024
BMW 430I 2024
BMW 530I 2024
BMW 740I 2024
BMW X3 2024
BMW X5 2024
BMW X7 2024
BMW XM 2024
UNKNOWN OR OTHER
Adapter Disc Return
MC-11021131-0001.pdf
SIB 52 09 25 (2025-07-22)
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
ELECTRICAL SYSTEM
The seat lumbar system Massage will not function if the module needs to be initialized. This can occur toeither the drivers and/or passenger side seat. Here is a list of possible faults: Seat pneumatics module front right SPNM _ VR 025908 – SPNMVR: Control unit is not coded 02590B – SPNMVR: Control unit is not encoded for the vehicle 806927 – SPNMVR: Installation location not taught in Seat pneumatics module front left SPNM _ VL 025308 – SPNMVL: Control unit is not coded 02530B – SPNMVL: Control unit is not encoded for the vehicle 8067A7 – SPNMVL: Installation location not taught in Seat Module Driver FAS SMFA 80301E – No seat adjustment because of engine start conditions Seat Module Passenger BFS SMBF 802C1E – No seat adjustment because of engine start conditions Seat Module Drivers Side Rear FAH SMFAH 802E1E – No seat adjustment because of engine start conditions Seat Module Passenger Side Rear BFH SMBFH 802A1E – No seat adjustment because of engine start conditions
MC-11020931-0001.pdf
SIB 63 04 18 (2025-07-21)
BMW 230I 2020,2024
BMW 5 SERIES 2023
BMW 5-SERIES GRAN TURISMO 2017
BMW 530E 2017,2018,2019,2020,2021,2022,2023
BMW 530I 2017,2018,2019,2020,2021,2022,2023,2024
BMW 535I 2017
BMW 540D 2018,2019,2020,2022,2023
BMW 540I 2017,2018,2019,2020,2021,2022,2023
BMW 550E 2020,2021
BMW 550I 2017
BMW 640I 2017,2018,2019,2020
BMW 740E 2016,2017,2018,2019
BMW 740I 2015,2016,2017,2018,2019,2020,2021,2022,2024
BMW 740LD 2015
BMW 740LE 2017,2018,2019,2020
BMW 740LI 2015,2016,2017,2018,2019,2020,2021,2022
BMW 740LXI 2015
BMW 745E 2020,2021,2022
BMW 745LE 2019,2020,2021,2022
BMW 750GS 2019
BMW 750I 2015,2016,2017,2018,2019,2020
BMW 750LI 2015,2016,2017,2018,2019,2020,2021,2022
BMW 750LXI 2015,2016,2017
BMW 750XI 2015,2016,2017
BMW 760LI 2015
BMW ALPINA XB7 2021,2022,2023
BMW B7 ALPINA 2018,2019,2020,2021
BMW C 400 X 2018
BMW F 850 GS ADVENTURE 2021
BMW F800 R 2017
BMW M5 2018,2019,2020,2021,2022,2023
BMW M550I 2017,2018,2019,2020,2021,2022,2023
BMW M760I 2017,2018,2019,2020,2021,2022
BMW M760LI 2021,2022
BMW X1 2020,2024
BMW X3 2017,2018,2019,2020,2021,2022,2023,2024
BMW X4 2018,2019,2020,2021,2022,2023,2024
BMW X5 2019,2020,2021,2022,2023,2024
BMW X5 HYBRID 2021,2022
BMW X6 2020,2021,2022,2023,2024
BMW X6 M 2020
BMW X7 2019,2020,2021,2022,2023,2024
VISIBILITY/WIPER
One or more of the LED daytime running lights are dim or discolored.
MC-11020927-0001.pdf
SIB 61 01 25 (2025-07-18)
BMW 530I 2024,2025
BMW 740I 2024
BMW M5 2025
UNKNOWN OR OTHER
During highly dynamic driving, washer fluid may be forced out of the windshield washer nozzles. This canlead to the washer fluid reservoir being completely emptied.
MC-11020928-0001.pdf
SIB 12 07 25 (2025-07-17)
BMW X5 2023,2024,2025
BMW X6 2023,2024,2025
BMW X7 2022,2023,2024
ENGINE
A quality check revealed that the DME in these vehicles has a programming error. This results in a deviation of the fuel-air mixture in the internal combustion engine.
MC-11020933-0001.pdf
SIB 52 07 25 (2025-07-17)
BMW M5 2025
STRUCTURE: BODY
The decorative trims on the head restraints of the drivers seat and front passenger seat cause groaning noises on any route, at any temperature, even in a slightly reclined position.
MC-11020932-0001.pdf
RECALL 25V470000 (2025-07-17)
Affecting 136 total vehicles built up to 2024-02-14
BMW I4 2022,2023
BMW I7 2023,2024
BMW IX 2022,2023,2024,2025
ELECTRICAL SYSTEM: PROPULSION SYSTEM: TRACTION BATTERY
BMW of North America, LLC (BMW) is recalling certain 2022-2025 IX, 2023-2024 I7, and 2022-2023 i4 vehicles. The high-voltage battery cell modules may not have been assembled properly, resulting in stress on the module frame and possible module failure.
SIB 66 03 25 (2025-07-14)
BMW 530I 2020,2021,2022,2023,2024,2025
BMW 740I 2020,2021,2022,2023,2024,2025
BMW IX 2021,2022,2023,2024,2025
BMW X1 2024,2025
BMW X2 2024,2025
BMW X5 2020,2021,2022,2023,2024,2025
BMW X6 2020,2021,2022,2023,2024,2025
BMW X7 2020,2021,2022,2023,2024,2025
BMW XM 2023,2024
ELECTRICAL SYSTEM
Check control message is displayed indicating the parking assistance systems have limited functionality dueto errors detected within PDC sensors. The warning indicates parking assistance features have limitedfunctionality while the errors continue to be detected. Following faults may be stored 8031BA Ultrasonic Sensor Rear Side Left Software Error 8031CO Ultrasonic Sensor Rear outer left Software error 8031AE Ultrasonic Sensor Rear Outer Right Software Error 8031A8 Ultrasonic Sensor Rear Side Right Software Error 8031B4 Ultrasonic Sensor Rear Middle Right Software Error 8031C6 Ultrasonic Sensor Rear Middle Left Software Error
MC-11020916-0001.pdf
SIB 34 10 25 (2025-07-14)
BMW 230I 2025
BMW 530I 2025
BMW 740I 2025
BMW M5 2025
BMW X1 2024
BMW X2 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
SERVICE BRAKES
After programming from the I-Levels between â¦24-03-505 and lower than â¦24-03-540 to I-Level â¦24-11-530 or higher, the following CCM may be displayed: CCM-2525: Brake system. Drive at moderate speed
MC-11020910-0001.pdf
SIB 66 09 25 (2025-07-14)
BMW X1 2025
BMW X2 2025
BMW X3 2025
VISIBILITY/WIPER
When the rear-view camera display is activated, moving objects appear to be juddering in the image.
MC-11020917-0001.pdf
SIB 24 01 25 (2025-07-10)
BMW X5 2025
BMW X6 2025
BMW X7 2025
ELECTRICAL SYSTEM
A software error in the transmission control unit (EGS) will prevent OBD/emissions related information from being read out with a scan tool.
MC-11020908-0001.pdf
SIB 18 02 25 (2025-07-10)
BMW X3 2025
STRUCTURE: BODY
After engine warm up there is a rattling noise coming from the rear muffler. During diagnosis, the rattle goesaway if the vehicle is put on a lift.
MC-11020907-0001.pdf
SIB 01 17 24 (2025-07-09)
BMW 750I 2015,2020
BMW 750LI 2020
BMW 850I 2019
BMW M5 2018
BMW M550I 2019,2020,2021
BMW M8 2020,2021
BMW M850I 2019,2020,2021
FUEL/PROPULSION SYSTEM
The Fuel Injector Condition-Specific Repair Coverage Program applies to qualifying repairs for the required replacement of one or more the fuel injectors which were determined to have failed due to a buildup of external corrosion in the engines center fuel injector bore area that resulted after this location was periodically contaminated by engine coolant residue over time. This special programs coverage is 15 years / 150,000 miles as determined from the vehicle’s original in-service / first delivery date.
MC-11021119-0001.pdf
SIB 32 03 24 (2025-07-08)
BMW IX 2021,2022,2023
STEERING
A check control (CC) message (Steering behavior. Drive moderately. Have it checked by the nearest service partner.) will light up and there will be a noticeable reduction in power steering assistance when parking.
MC-11020909-0001.pdf
SIB 61 11 25 (2025-07-08)
BMW X3 2025
ELECTRICAL SYSTEM
The vehicle alarm will randomly activate on its own.
MC-11020914-0001.pdf
SIB 61 33 23 (2025-07-03)
BMW I4 2023,2024
BMW I7 2023,2024
ELECTRICAL SYSTEM
The Combined Charging Unit (CCU) may not have been built to specifications.
MC-11020915-0001.pdf
SIB 51 12 23 (2025-07-02)
BMW 230I 2020
BMW 330I 2020,2023,2024,2025
BMW 430I 2020,2023,2024,2025
BMW X5 2020,2023,2024,2025
BMW X6 2020,2023,2024,2025
BMW X7 2020,2023,2024,2025
STRUCTURE: BODY
After carrying out the vehicle test, one or more of the stored faults indicate that the operation of the front bottom active air flap is obstructed or blocked.
MC-11020911-0001.pdf
SIB 06 34 25 (2025-07-02)
BMW IX 2024
WHEELS
Wheel Insert Return
MC-11020073-0001.pdf
SIB 61 10 25 (2025-07-02)
BMW X1 2024
BMW X2 2024
STRUCTURE: BODY
The washer fluid reservoir (filler neck circled)may be leaking, and drains out through thewheel well liner. When the vehicle is parked, apuddle of washer fluid may be present underthe right front corner.
MC-11020913-0001.pdf
SIB 84 03 25 (2025-07-02)
BMW XM 2024
ELECTRICAL SYSTEM
When making a call through the vehicle systems with a connected mobile device, electrical interference noise from accelerating or braking is heard by the other party (recipient). No interference can be heard in thevehicle.
MC-11020918-0001.pdf
SIB 11 03 25 (2025-07-01)
BMW 740I 2024
BMW 760I 2025
BMW X5 2024,2025
BMW X6 2024,2025
BMW X7 2024,2025
BMW XM 2024
ENGINE
The Check Engine Oil Level warning is displayed while driving due to one of the following: Shortly after a detailed measurement has been carried out Shortly after engine oil has been topped up Shortly after an engine oil service has been carried out
MC-11020906-0001.pdf
SIB 41 05 25 (2025-06-27)
BMW 230I 2024
BMW 530I 2024
BMW 740I 2024
BMW I4 2024
BMW I5 2024
BMW I7 2024
BMW X1 2024
BMW X2 2024
BMW XM 2024
STRUCTURE: BODY
While attempting to fuel/charge the vehicle,the fuel/charge door will not open.
MC-11020066-0001.pdf
SIB 06 37 25 (2025-06-25)
BMW X3 2024
UNKNOWN OR OTHER
Storage Net Return
MC-11020076-0001.pdf
SIB 06 36 25 (2025-06-23)
BMW 740I 2024
BMW 750E 2024
BMW I7 2024
ENGINE
Hydrobearing Return
MC-11020075-0001.pdf
SIB 52 08 25 (2025-06-17)
BMW 740I 2024
SEATS
The rear seat leg rest can fold down when a heavy load/weight is placed on it.
MC-11020067-0001.pdf
SIB 06 35 25 (2025-06-17)
BMW M5 2020
BMW M8 2020
BMW X6 M 2020
ENGINE
Engine Return
MC-11020074-0001.pdf
SIB 65 13 25 (2025-06-16)
BMW X3 2025
ELECTRICAL SYSTEM
In certain situations, a newly installed central woofer(s) (bass speaker) will not function.
MC-11020068-0001.pdf
RECALL 25V395000 (2025-06-16)
Affecting 71286 total vehicles
BMW I4 2022,2023,2024
BMW I4 EDRIVE35 2025
BMW I4 EDRIVE40 2025
BMW I5 2024
BMW I7 2023,2024
BMW IX 2022,2023,2024
ELECTRICAL SYSTEM: PROPULSION SYSTEM: TRACTION MOTOR: CONTROLLER: SOFTWARE
BMW of North America, LLC (BMW) is recalling certain 2022-2025 i4, 2022-2024 IX, 2023-2024 I7, and 2024 I5 vehicles. The electric drive motor software may shut down the high-voltage system, causing a loss of drive power.
RCRIT-25V395-8044.pdf
SIB 37 02 25 (2025-06-12)
BMW X5 2025
BMW X6 2025
BMW X7 2025
SUSPENSION
The air line on the air suspension supply system may not be properly installed. In the event of a fault, residual pressure is maintained in the struts and corresponding check control message.
MC-11019565-0001.pdf
SIB 72 04 17 (2025-06-11)
BMW 530E 2018,2019,2020
BMW 530I 2017,2018,2019,2020
BMW 540D 2018,2019,2020
BMW 540I 2017,2018,2019,2020
BMW 640I 2018,2019,2020
BMW 740E 2017,2018,2019
BMW 740I 2017,2018,2019,2020
BMW 740LI 2016,2017
BMW 745E 2020
BMW 750I 2018,2019
BMW 750LI 2016,2017,2018,2019
BMW B7 ALPINA 2018,2019,2020
BMW C 400 X 2018
BMW F800 R 2017
BMW M5 2018,2019,2020,2021,2022
BMW M550I 2017,2018,2019,2020
BMW M760I 2017,2018,2019,2020
BMW X3 2018,2019,2020
BMW X4 2019,2020
BMW X5 2019,2020
AIR BAGS
The Supplemental Restraint Systems (SRS) Front Passengers Seat Occupancy Capacitive Interior Sensor (CIS) Mat for defects in materials and/or workmanship that causes a false seat occupancy alert to occur has been extended to 10 years / 120,000 miles as determined from the vehicle’s original inservice / first delivery date.
MC-11019578-0001.pdf
SIB 34 04 25 (2025-06-11)
BMW 530I 2022,2023,2024
BMW 740I 2022,2023,2024
BMW X1 2022,2023,2024
BMW X2 2023,2024
BMW X5 2022,2023,2024
BMW X6 2022,2023,2024
BMW X7 2022,2023,2024
ELECTRICAL SYSTEM
As a result of a data input error, certain fault memories are permanently stored. The permanent storage offault memories does not comply with the legal specifications of the authority (California Air Resources Board CARB). The fault has no effect on the use of the vehicle by the customer.
MC-11019563-0001.pdf
SIB 72 03 25 (2025-06-11)
BMW X3 2018,2019
BMW X4 2019
AIR BAGS
The Supplemental Restraint Systems (SRS) Front Passengers Seat Occupancy Capacitive Interior Sensor (CIS) Mat for defects in materials and/or workmanship that causes a false seat occupancy alert to occur has been extended to 10 years / 120,000 miles as determined from the vehicle’s original in-service / first delivery date.
MC-11019577-0001.pdf
SIB 72 02 25 (2025-06-11)
BMW 330E 2021
BMW 330I 2019,2020,2021
BMW 340I 2020
BMW M340I 2021
BMW X3 2019
BMW X4 2019
AIR BAGS
The Supplemental Restraint Systems (SRS) Front Passengers Seat Occupancy Capacitive Interior Sensor (CIS) Mat for defects in materials and/or workmanship that causes a false seat occupancy alert to occur has been extended to 10 years / 120,000 miles as determined from the vehicle’s original in-service / first delivery date.
MC-11019576-0001.pdf
SIB 12 04 25 (2025-06-11)
BMW 530I 2022,2023,2024,2025
BMW 740I 2022,2023,2024,2025
BMW M5 2023,2025
BMW M550I 2017
BMW X1 2021,2022,2023
BMW X2 2023
BMW X5 2022,2023,2024,2025
BMW X6 2022,2023
BMW X7 2021,2022,2023
ELECTRICAL SYSTEM
EMISSIONS RECALL 25E-A02: PROGRAM CONTROL UNITS
MC-11019554-0001.pdf
SIB 32 07 25 (2025-06-11)
BMW X5 2025
SUSPENSION
Rattling/knocking noise from the front axle at low speeds of less than 15 mph. The noises are induced by driving over rough road surface or by brake operation. The noises occur during straight ahead driving or cornering.
MC-11019562-0001.pdf
SIB 34 07 25 (2025-06-11)
BMW 530I 2025
BMW 740I 2025
BMW I5 2025
BMW I7 2025
BMW XM 2023
SERVICE BRAKES
A loud click- type noise can be heard from the rear axle brakes when driving off forwards, and/or in reverse.
MC-11019564-0001.pdf
SIB 65 11 25 (2025-06-11)
BMW 230I 2025
BMW 330I 2025
BMW 430I 2025
BMW IX 2025
BMW X1 2025
BMW X7 2025
BMW XM 2024
ELECTRICAL SYSTEM
When navigation is selected, only the start animation with the text Starting navigation system… isdisplayed. The Navigation application does not start. This only applies to vehicles where Navigation hasbeen enabled and has been verified to work previously.
MC-11019572-0001.pdf
SIB 65 14 25 (2025-06-11)
BMW 230I 2025
BMW X1 2025
BMW X2 2025
BMW X3 2025
ELECTRICAL SYSTEM
After the software upgrade to â¦24-11-5xx, the customer is no longer able to log onto Alexa in the vehicle.The system reacts to the customers voice (a blue line appears on the central display), but Alexa does notwork.
MC-11019573-0001.pdf
SIB 27 02 20 (2025-06-06)
BMW 3 SERIES 2023
BMW 330I 2019,2020,2024,2025
BMW 4 SERIES 2023
BMW 430I 2020,2025
BMW 5 SERIES 2023
BMW 530E 2018,2019,2020
BMW 530I 2017,2018,2019,2020,2023,2024,2025
BMW 540D 2018,2019,2020
BMW 540I 2017,2018,2019,2020
BMW 640I 2018,2019,2020
BMW 740E 2017,2018,2019
BMW 740I 2017,2018,2019,2020,2023,2024,2025
BMW 740LI 2016,2017
BMW 745E 2020
BMW 750I 2018,2019
BMW 750LI 2016,2017,2018,2019
BMW 8 SERIES 2023
BMW 840I 2020,2024,2025
BMW B7 ALPINA 2018,2019,2020
BMW C 400 X 2018
BMW F800 R 2017
BMW M340I 2020
BMW M5 2018,2019,2020
BMW M550I 2017,2018,2019,2020
BMW M760I 2017,2018,2019,2020
BMW M8 2020
BMW M8 GRAN COUPE 2020
BMW M850I 2019,2020
BMW M850XI 2019
BMW X3 2018,2019,2020,2023,2024,2025
BMW X4 2019,2020,2023,2024,2025
BMW X5 2019,2020,2023,2024,2025
BMW X6 2020,2023,2024,2025
BMW X7 2019,2020,2023,2024,2025
BMW XM 2024
POWER TRAIN
There is a jerking or shuddering during either or both of the following: Cornering or accelerating from low speeds Driving with low to medium loads
MC-11019579-0001.pdf
SIB 12 01 25 (2025-06-06)
BMW M2 2024
BMW M3 2022,2023,2024,2025
BMW M4 2022,2023,2024,2025
BMW X3 2022,2023,2024,2025
BMW X4 2022,2023,2024,2025
ELECTRICAL SYSTEM
EMISSIONS RECALL 25E-A03: PROGRAM CONTOL UNITS (DME)
MC-11019550-0001.pdf
SIB 64 06 25 (2025-06-06)
BMW I4 2024
BMW I5 2024
BMW I7 2024
ENGINE
A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in the failure of the electric auxiliary heater.
MC-11019570-0001.pdf
SIB 61 09 25 (2025-06-06)
BMW X3 2025
VISIBILITY/WIPER
Windshield wiping quality has decreased or the wiper arm is contacting the hood.
MC-11019568-0001.pdf
SIB 63 03 25 (2025-06-06)
BMW X3 2025
EXTERIOR LIGHTING
G45 vehicles built with option codes 552 (Full LED Lights with Cornering Lights), or 3MF (M ShadowlineLights), the headlights height setting might not be adjusted correctly.
MC-11019569-0001.pdf
SIB 64 07 25 (2025-06-06)
BMW I4 2024
ENGINE
A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in the failure of the electric auxiliary heater.
MC-11019571-0001.pdf
SIB 65 35 24 (2025-06-03)
BMW 230I 2024
BMW 330I 2024,2025
BMW 430I 2024,2025
BMW 530I 2024,2025
BMW 740I 2025
BMW IX 2024,2025
BMW X1 2024,2025
BMW X2 2024,2025
BMW X3 2024,2025
BMW X4 2025
BMW X5 2024,2025
BMW X6 2024,2025
BMW X7 2024,2025
BMW XM 2024
ELECTRICAL SYSTEM
Customers may report that the Central Information Display (CID) side of the Multifunction Display flickersonce on and off. This flickering is not continuous but may occur once every 15 to 50 seconds. No fault memory entry is stored for this customer complaint.
MC-11019580-0001.pdf
SIB 36 02 25 (2025-06-02)
BMW X1 2023,2024,2025
BMW X2 2024,2025
STEERING
A knocking/thumping noise can be heard during left/right steering wheel movements while stationary or atlow speeds, and can also be felt in the steering wheel. The noise occurs at high interior temperatures above 86°F. When the vehicle interior cools down, the noise is diminished.
MC-11019561-0001.pdf
SIB 41 04 25 (2025-06-02)
BMW IX 2022,2023,2024
STRUCTURE: BODY
Water sloshing is heard in the vehicles body when accelerating and braking.
MC-11019566-0001.pdf
SIB 54 04 25 (2025-06-02)
BMW 530I 2025
BMW 740I 2025
BMW M5 2025
ELECTRICAL SYSTEM
The Sky Lounge sunshade does not open/close. Concern may be intermittent. The following fault codes are stored in the FZD (Roof Centre Function) control module during a vehicle test: 0302A0- ESH (electrical sunshade): No standardization system 03029C- ESH (electrical sunshade): No init because boundary conditions not valid (motordiver)
MC-11019567-0001.pdf
SIB 65 16 25 (2025-06-02)
BMW 230I 2025
BMW X1 2025
BMW X2 2025
BMW X3 2025
ELECTRICAL SYSTEM
Customer may discover that after a sleep cycle, any paired Bluetooth devices may have been deleted from the head unit and any personalized menu settings may have been set back to factory.
MC-11019574-0001.pdf
SIB 61 05 25 (2025-05-31)
BMW X3 2025
ELECTRICAL SYSTEM
48V Battery Threaded Connections
MC-11018727-0001.pdf
SIB 61 08 25 (2025-05-30)
BMW I5 2025
ELECTRICAL SYSTEM
The operating time value was written too high in the Storage Management Electronics (SME) during thehigh-voltage battery End Of Line (EOL) test. The excessive operating hours input results in a significant limitation in the charging capacity when vehicleis be charged with DC.
MC-11018729-0001.pdf
SIB 66 07 25 (2025-05-30)
BMW 230I 2024
BMW 330I 2024
BMW 430I 2024
BMW 530I 2024
BMW 740I 2024
BMW IX 2024
BMW X1 2024
BMW X2 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
ELECTRICAL SYSTEM
The speed limit warning adopted speed, which is set by the customer, is automatically reverting to lowervalue after an extended duration of the sleep cycle.
MC-11018732-0001.pdf
SIB 52 06 25 (2025-05-29)
BMW X7 2024
STRUCTURE: BODY
While attempting to unbolt the third-row seat to perform, or to gain access to perform another required repair, one or more of the bolts may not easily loosen. Applying addition force to loosen the bolts may cause the seat anchor body-nuts to break free from their welds. The bolts will then just spin, not allowing the seat to be removed.
MC-11018726-0001.pdf
SIB 61 06 25 (2025-05-29)
BMW I4 2023
ELECTRICAL SYSTEM
The Check Control message (CCM): “You can continue driving. Drivetrain (00029) is displayed, togetherwith the following fault code: 224188 Accelerator pedal module, pedal sensor, sensor 1, sensor 2: Signals implausible Note: There may or may not be a drivability complaint associated with this fault.
MC-11018728-0001.pdf
SIB 51 10 25 (2025-05-28)
BMW X5 2024
BMW X6 2024
BMW X7 2024
STRUCTURE: BODY
A whistling sound is heard coming from the front end of the vehicle while driving at various speeds.
MC-11018725-0001.pdf
SIB 12 05 25 (2025-05-24)
BMW 330I 2024
BMW X5 2024
BMW X7 2024
ELECTRICAL SYSTEM
Moisture may enter the start generator supply line and cause corrosion inside the line.
MC-11018723-0001.pdf
SIB 06 33 25 (2025-05-23)
BMW X3 2025
STRUCTURE: BODY
Inspection and Return – Diffuser Trim
MC-11018833-0001.pdf
SIB 12 06 25 (2025-05-22)
BMW 740I 2024
FUEL/PROPULSION SYSTEM
The electrical connector for the bank 1 high pressure pump may not have been locked correctly.
MC-11018545-0001.pdf
SIB 06 32 25 (2025-05-21)
BMW 330I 2024
BMW 430I 2024
BMW I4 2024
VISIBILITY/WIPER
Inspection and Return – Linkage for Wiper System
MC-11018835-0001.pdf
SIB 65 12 25 (2025-05-20)
BMW X3 2025
ELECTRICAL SYSTEM
In certain situations, during the first 40 seconds of vehicle operation, the turn signal sound may be delayedor out of sync with the visual indicator.
MC-11018548-0001.pdf
SIB 65 15 25 (2025-05-20)
BMW 230I 2024
BMW 330I 2024
BMW 430I 2024
BMW 530I 2024
BMW 740I 2024
BMW IX 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
ELECTRICAL SYSTEM
When initiating a phone call to a specific saved contact, Intelligent Personal Assistant may not be able tolocate the contact or may call the incorrect contact.
MC-11018549-0001.pdf
SIB 01 04 25 (2025-05-19)
BMW 330E 2023,2024
BMW 530E 2023
BMW 750E 2023
BMW X5 HYBRID 2022
BMW XM 2023,2024
ENGINE
The high-voltage battery assemblys refrigerant circuit expansion valves limited warranty for defects in materials and/ or workmanship has been extended to 15 years / 150,000 miles as determined from theoriginal first in-service / delivery date.
MC-11018560-0001.pdf
SIB 01 08 25 (2025-05-14)
BMW 330E 2020,2021,2022
BMW 330I 2019,2020,2021,2022
BMW X5 2020,2021,2022
BMW X6 2020,2021,2022
BMW X7 2019,2020,2021,2022
STRUCTURE: BODY
A vehicle listed above may arrive with a Check Control Message (CCM), and/or malfunction indicator lamp(MIL) illuminated. After carrying out the vehicle test, one or more of the stored faults indicate that the operation of the front bottomactive air flap is obstructed or blocked. Thoroughly inspect the front bottom air flap, when applicable, remove any contamination that is found caught inand between the bottom air flaps (aka blinds) and/or the housing.
MC-11018730-0001.pdf
SIB 84 02 25 (2025-05-13)
BMW 230I 2025
BMW 330I 2024
BMW 430I 2024
BMW 740I 2024
BMW IX 2024
BMW X1 2024
BMW X2 2024
BMW X3 2024
BMW X4 2024
BMW X5 2025
BMW X6 2025
BMW X7 2025
BMW XM 2024
ELECTRICAL SYSTEM
When making phone calls via BMW Bluetooth (not Apple CarPlay) in the vehicle, the person in the calloutside the vehicle hears a distorted voice reproduction.
MC-11018554-0001.pdf
SIB 33 02 25 (2025-05-12)
BMW X3 2025
POWER TRAIN
Sufficient grease was not applied to the left rear axle shaft. The velocity joints could overheat after a short amount of driving
MC-11018517-0001.pdf
SIB 65 09 25 (2025-05-08)
BMW 230I 2024
BMW 330I 2024
BMW 430I 2024
BMW 530I 2024
BMW 740I 2024
BMW IX 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
ELECTRICAL SYSTEM
Customer may complain that Projected Modes (Apple CarPlay/Android Auto) do not connect in the vehicle. Itis found that the WiFi in the vehicle is also not active and cannot be turned on.
MC-11018546-0001.pdf
SIB 06 31 25 (2025-05-07)
BMW 230I 2024
BMW X1 2024
BMW X2 2024
POWER TRAIN
Inspection and Return – Output Drive Repair Kit
MC-11018832-0001.pdf
SIB 16 01 25 (2025-05-05)
BMW 330I 2024,2025
BMW 430I 2024,2025
FUEL/PROPULSION SYSTEM
Please have the Integrated Fuel Module control unit (IFM) programmed in the vehicles concerned(according to the vehicle identification number selection), if possible, before vehicle delivery.
MC-11018511-0001.pdf
SIB 36 02 24 (2025-05-02)
BMW X3 2025
WHEELS
Under certain circumstances, the inner liner of the tire may become detached, which can result in a slowloss of inflation pressure. This loss in inflation pressure is detected and displayed accordingly via the tirepressure monitoring system.
MC-11018519-0001.pdf
SIB 32 02 25 (2025-05-02)
BMW 530I 2024,2025
BMW 540I 2025
BMW 740I 2024,2025
BMW I5 2024,2025
BMW I7 2024,2025
BMW M5 2025
STEERING
Parts of the steering shaft universal joint may have been joined together without having beengreased. As a result, there can be audible squeaking and cracking noises. In some cases, moresteering force is required.
MC-11018513-0001.pdf
SIB 32 04 25 (2025-05-02)
BMW 230I 2024
BMW 330I 2024
BMW 430I 2024
BMW X3 2024
BMW X4 2024
BMW Z4 2023
STEERING
After prolonged straight-ahead driving (e.g. highway driving), there may be a temporary, slightly noticeable increase in steering forces when steering out of the steering wheel center position. This minimally noticeable increase in steering forces is perceived as a slight, brief resistance. After overcoming this brief resistance when steering out of the steering wheel center position, no permanent increase in steering forces is noticeable.
MC-11018514-0001.pdf
SIB 32 05 25 (2025-05-02)
BMW X3 2024
STEERING
Knocking/thumping noise during steering wheel movements and returning to the center position. See attached video V32 05 25 Column noise.
MC-11018515-0001.pdf
SIB 34 06 25 (2025-05-02)
BMW M3 2024
BMW M4 2024
BMW M8 2024
BMW X3 2024
BMW X4 2024
BMW X5 2024
BMW X6 2024
SERVICE BRAKES
Brake groaning noises heard at the rear axle at slow speeds, i.e. close to standstill, stop and go driving;when parking or maneuvering.
MC-11018518-0001.pdf
SIB 31 05 25 (2025-05-01)
BMW XM 2024
SUSPENSION
The torsion spring may break at the point where it is connected to the active front stabilizer (anti-roll bar)links. A broken active stabilizer (anti-roll bar) will cause noise as you continue driving.
MC-11018512-0001.pdf
SIB 17 01 25 (2025-04-30)
BMW I5 2025
ENGINE
The coolant hose which runs from the combined charging unit (CCU) to the front electric motors housingmay develop a leak at the motor end of the hose.
MC-11017503-0001.pdf
SIB 66 17 19 (2025-04-30)
BMW X3 2017,2018,2019,2020,2021
BMW X4 2018,2019,2020,2021
SERVICE BRAKES
The vehicle applies the brakes on its own when reversing onto an inclined roadway or driveway. This appliesonly to the situation where the Active PDC option is activated via the iDrive.
MC-11017504-0001.pdf
SIB 51 30 19 (2025-04-29)
BMW 3 SERIES 2023
BMW 330E 2020,2021,2022,2023
BMW 330I 2020,2021,2022,2023,2024,2025
BMW 340I 2020,2023
BMW 530I 2020,2021,2022,2023,2024,2025
BMW X1 2020,2021,2022,2023,2024,2025
BMW X3 2017,2018,2019,2020,2021
BMW X5 2014,2015,2016,2017,2018,2019,2020,2021,2022,2023, 2024,2025
BMW X5 M 2018
BMW X6 2015,2016,2017,2018,2019,2020,2021,2022,2023,2024, 2025
BMW X6 M 2015,2016,2017,2018,2019,2020
STRUCTURE: BODY
A groaning noise is present from the door frame of any door, most commonly when driving over rough roadsor during body flex. This situation may be worse in vehicles which are regularly waxed in th e area of the door jamb.
MC-11017506-0001.pdf
SIB 51 08 25 (2025-04-29)
BMW 230I 2025
STRUCTURE: BODY
During vehicle assembly, the incorrect kidne ygrille trim finish (highlighted in orange) was installed.
MC-11017301-0001.pdf
SIB 06 30 25 (2025-04-29)
BMW 330I 2020
BMW 530I 2020
BMW X3 2020
BMW X4 2020
ENGINE
Coolant Pump Return
MC-11017562-0001.pdf
SIB 65 08 25 (2025-04-28)
BMW 230I 2025
BMW 330I 2025
BMW 430I 2025
BMW X1 2025
BMW X2 2025
BMW X5 2025
BMW X6 2025
BMW X7 2025
BMW XM 2024
BMW Z4 M40I 2025
ELECTRICAL SYSTEM
Central Information Display (CID) side of the Multifunction Display may intermittently black out.
MC-11017569-0001.pdf
SIB 41 02 25 (2025-04-25)
BMW X1 2023,2024,2025
BMW X2 2023,2024
STRUCTURE: BODY
While driving on a smooth and/or uneven road, a popping sound is heard from the bottom of the C-pillar area. This can occur on one and/or both sides on the vehicle C-pillars.
MC-11017277-0001.pdf
SIB 51 09 25 (2025-04-25)
BMW X3 2022,2023,2024
STRUCTURE: BODY
Oxidation/corrosion on the tailgate latchelectrical connector and/or mechanical cable. This is caused by pressure washing thetailgate for a long period of time at closedistance, resulting in water entering thevehicle through the gaps of the tailgate.
MC-11017278-0001.pdf
SIB 63 02 22 (2025-04-25)
BMW 430I 2021
VISIBILITY/WIPER
Excessive condensation in one or both headlights.
MC-11017571-0001.pdf
SIB 51 02 24 (2025-04-22)
BMW 530I 2023,2024,2025
BMW I5 2024
BMW X3 2024,2025
STRUCTURE: BODY
A squeaking sound is heard when folding either of the exterior mirrors assemblies in or out.
MC-11017280-0001.pdf
SIB 24 02 24 (2025-04-18)
BMW 530I 2024
BMW X5 2024
BMW X7 2024
POWER TRAIN
Due to a manufacturing issue, the torque on the bolts of the transmission Mechatronics was not carried outaccording to the specification. The faulty torquing can cause a malfunction within the transmission, and as a result, the emergencyoperation of the transmission.
MC-11017286-0001.pdf
SIB 61 02 25 (2025-04-18)
BMW X5 2024,2025
BMW X6 2024,2025
BMW X7 2024,2025
ELECTRICAL SYSTEM
Due to unfavorable tolerances, the Power Control Unit (PCU) may switch off under heavy loads and nolonger charge the Lithium-Ion (Li-Ion) Auxiliary (AUX) battery. This leads to the failure of the roll stabilization,and loss of communication to the EARS modules (S 0421 & S 0422).
MC-11017283-0001.pdf
SIB 51 07 25 (2025-04-17)
BMW 430I 2023,2024,2025
STRUCTURE: BODY
The trunk lid trim panel may partially comeloose/dangle (red arrows show the mostprevalent areas).
MC-11017284-0001.pdf
RECALL 25V247000 (2025-04-16)
Affecting 26 total vehicles
BMW X3 2025
SERVICE BRAKES, HYDRAULIC: FOUNDATION COMPONENTS: DISC
BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 xDrive vehicles. The front brake discs may have been damaged during transport before they were installed on the vehicle.
RCRIT-25V247-9211.pdf
SIB 51 05 25 (2025-04-15)
BMW X3 2025
STRUCTURE: BODY
The pins for the pull handle may have not been correctly plastic welded to the front passenger door panel.
MC-11017296-0001.pdf
SIB 01 07 25 (2025-04-15)
BMW 330E 2021,2022
BMW X5 HYBRID 2021,2022
STRUCTURE: BODY
The Radiator Grilles Lower Active Air Flap Assembly limited warranty for defects in materials and/or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.
MC-11017102-0001.pdf
SIB 01 03 25 (2025-04-15)
BMW 330I 2019,2020,2021,2022
BMW M340I 2020,2021,2022
BMW X5 2019,2020,2021,2022
BMW X6 2020,2021,2022
BMW X7 2019,2020,2021,2022
STRUCTURE: BODY
The Radiator Grilles Lower Active Air Flap Assembly limited warranty for defects in materials and/or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.
MC-11017103-0001.pdf
SIB 06 29 25 (2025-04-15)
BMW 530I 2025
BMW 740I 2025
STEERING
Swivel Joint Return
MC-11017559-0001.pdf
SIB 34 04 25 (2025-04-09)
BMW X3 2025
SERVICE BRAKES
Delivery Stop: Front Brake Disc
MC-11017303-0001.pdf
SIB 34 02 25 (2025-04-03)
BMW 330I 2025
BMW 430I 2025
BMW M240I 2025
SERVICE BRAKES
Due to a manufacturing defect, there might be an internal leakage of the brake fluid expansion tank. In therare case that there is a leakage, the filling level sensor might malfunction over a relatively long period oftime .
MC-11017082-0001.pdf
SIB 65 01 25 (2025-04-02)
BMW X3 2025
UNKNOWN OR OTHER
The BMW Intelligent Personal Assistant does not activate or once activated does not acknowledge voicecommands.
MC-11017087-0001.pdf
RECALL 25V202000 (2025-04-01)
Affecting 4557 total vehicles
BMW 330I 2025
BMW 330I XDRIVE 2025
BMW 430I 2025
BMW 430I XDRIVE 2025
BMW 530I 2025
BMW 530I XDRIVE 2025
BMW X3 2025
ELECTRICAL SYSTEM: STARTER ASSEMBLY
BMW of North America, LLC (BMW) is recalling certain 2025 330i, 330i xDrive, 530i, 530i xDrive, 4 Series Coupe (430i, 430i xDrive), 4 Series Convertible (430i, 430i xDrive), 4 Series Gran Coupe (430i, 430i xDrive) and X3 30 xDrive vehicles. The electrical connection between the starter-generator and battery may come loose.
RCRIT-25V202-3123.pdf
SIB 17 01 24 (2025-03-31)
BMW I4 2022,2023,2024
BMW I5 2024,2025
BMW I5 EDRIVE40 2024
BMW I7 2023,2024,2025
BMW IX 2021,2022,2023,2024,2025
ENGINE
There is coolant leaking from under the car Low heater output Possible Check Control message Drive, you can continue driving (ID49) Possible fault codes stored in these BEV vehicles: 224163 Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA – Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 80124F Electric auxiliary heater: Communication in electric auxiliary heater faulty 224F60 – Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection 224111 – Cooling system for power electronics: Coolant loss detected 224107 – Cooling system for high-voltage battery unit, component protection: Detection of coolant loss
MC-11016419-0001.pdf
SIB 51 16 24 (2025-03-31)
BMW 430I 2024
UNKNOWN OR OTHER
On G22 and G23 xDrive vehicles, the xDriveemblem was not installed on the left side ofthe trunk (circled). Only the 430i emblemwas installed to the right side of the trunk. Without the xDrive emblem on the trunk, thecurrent emblem on the vehicle corresponds tovehicles without all-wheel drive.
MC-11016437-0001.pdf
SIB 52 19 23 (2025-03-27)
BMW X7 2022,2023,2024,2025
SEATS
In vehicles equipped with the second row 60% / 40% split seat, the flex cable assembly can come out of the seat rail mechanism (circled). This stops the forwards and backwards travel of the seat.
MC-11016438-0001.pdf
SIB 34 01 25 (2025-03-27)
BMW 530I 2025
BMW 740I 2025
BMW I5 2025
SERVICE BRAKES
The parking brake actuator cannot be activated or deactivated due to a failed weld. Check Control message Parking brake failed. When parking, secure the vehicle against rolling away. Mustbe checked by the Service Partner. The vehicle is still held by the unaffected side and the transmission lock.
MC-11016432-0001.pdf
SIB 54 02 25 (2025-03-27)
BMW Z4 2021,2022,2023
STRUCTURE: BODY
While driving on an uneven road, a clickingsound is heard from the front bow/cowl panelarea of the convertible top.
MC-11016441-0001.pdf
SIB 63 01 25 (2025-03-27)
BMW X7 2023,2024,2025
EXTERIOR LIGHTING
Contamination/condensation in the uppersection of the Daytime Running Lights (DRL)headlight(s); drivers headlamp shown.
MC-11016444-0001.pdf
SIB 06 25 25 (2025-03-26)
BMW 330I 2020
BMW 430I 2020
BMW 530I 2020
BMW 740I 2020
BMW X1 2020
BMW X2 2020
BMW X3 2020
BMW X5 2020
BMW X6 2020
BMW Z4 2020
ENGINE
Bearing Shell Return
MC-11016470-0001.pdf
SIB 06 23 25 (2025-03-24)
BMW 330I 2025
BMW 430I 2025
UNKNOWN OR OTHER
Floor Mat Return
MC-11015869-0001.pdf
SIB 06 24 25 (2025-03-24)
BMW 330I 2024
BMW 430I 2024
BMW I4 2024
VISIBILITY/WIPER
Wiper System Return
MC-11015873-0001.pdf
SIB 28 01 23 (2025-03-21)
BMW X1 2022,2023,2024,2025
BMW X2 2022,2023,2024,2025
POWER TRAIN
Check control message (790) Emergency gearbox release activated is displayed immediately after starting the engine. This applies only to U11 equipped with the 7-speed M-DCT transmission.
MC-11015855-0001.pdf
SIB 06 13 25 (2025-03-21)
BMW 330I 2025
BMW 430I 2025
BMW 530I 2025
BMW X3 2025
BMW X6 2025
ENGINE
Starter Return
MC-11015854-0001.pdf
SIB 51 07 23 (2025-03-21)
BMW X5 2024
BMW X6 2024
BMW X7 2024
STRUCTURE: BODY
This bulletin outlines known areas of upper and lower tailgate functionality, operational noise, or static noise for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting complaints from the tailgate area. This bulletin and the associated attachment are designed to provide one single diagnostic resource for troubleshooting all known issues related to the tailgate of the BMW Sports Activity Vehicles/Coupes (SAV/SAC) which have quality improvement measures already in place.
MC-11015856-0001.pdf
SIB 52 04 25 (2025-03-19)
BMW X2 2024,2025
SEATS
Customer states he/she sees a check control message for the rear seat not being locked. The following fault codes stored in the air bag ACSM6 control module: 930C19 – Backrest Sensor right 2nd seat row: open circuit 930D76 – Function rear restraint system restricted
MC-11015841-0001.pdf
SIB 64 03 25 (2025-03-13)
BMW X5 2024,2025
BMW XM 2023,2024
ELECTRICAL SYSTEM
Check Engine Light is illuminated, check control message indicates bring in for service. The faultsthemselves and the Malfunction Indicator Lamp (MIL) have no functional effect on the vehicle. There are multiple missing message fault codes (DTC) stored in the integrated automatic heating/airconditioning system (IHKA) control unit. These faults may include: E71458 – AC-LIN: Message EKMV20 E71459 – AC-LIN: Message EDH NOTE: These faults are secondary message faults and may not show up when performing the vehicle test.They will show up when looking at the operation report.
MC-11015821-0001.pdf
SIB 01 13 23 (2025-03-12)
BMW ALPINA XB7 2022,2023
BMW B7 ALPINA 2021
BMW X5 2019,2020,2021,2022,2023
BMW X6 2019,2020,2021,2022
BMW X6 M 2020
BMW X7 2019,2020,2021,2022,2023
UNKNOWN OR OTHER
CLASS ACTION SETTLEMENT: F95 F96 G05 G06 G07 FRONT CENTER CONSOLE CUPHOLDER
MC-11015850-0001.pdf
SIB 06 21 25 (2025-03-12)
BMW 740I 2023,2024
BMW XM 2023,2024
EXTERIOR LIGHTING
LED Module Return
MC-11015862-0001.pdf
RECALL 25V154000 (2025-03-12)
Affecting 192 total vehicles built between 2025-02-06 and 2025-02-07
BMW X3 2025
ELECTRONIC STABILITY CONTROL (ESC)
BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 xDrive and X3 M50 xDrive vehicles. The rear brake hoses may leak, causing a loss of rear brake function, and a loss of the Antilock Brake System (ABS) and the Dynamic Stability Control (DSC) system.
RCRIT-25V154-6825.pdf
SIB 41 01 25 (2025-03-10)
BMW 230I 2025
STRUCTURE: BODY
A crack may have formed in the upper left corner of the trunk opening (circled in red),where the quarter panel contacts the left lower corner of the rear window and trunk water channel. Illustration of the inward-facing metal shows the general location of the possible crack, though the area to be checked in the Procedure is on the back side/outward-facing surface. The PVC seam sealant applied to the water channel may not sufficiently seal the channel in the presence of the crack, resulting in a small water leak into the trunks interior.
MC-11015553-0001.pdf
SIB 32 03 25 (2025-03-10)
BMW X3 2024
BMW X4 2024
ELECTRICAL SYSTEM
Customer states that the steering wheel heating is inoperative. Fault code 30490 Missing LIN slave is stored in Body Domain Controller.
MC-11015552-0001.pdf
SIB 06 16 25 (2025-03-06)
BMW 230I 2024
BMW 330I 2024
BMW 430I 2024
UNKNOWN OR OTHER
Central Bass Right Return
MC-11015860-0001.pdf
SIB 26 01 25 (2025-03-06)
BMW X3 2025
POWER TRAIN
Delivery Stop – Driveshaft
MC-11016420-0001.pdf
SIB 34 02 25 (2025-03-06)
BMW 230I 2025
BMW 330I 2025
BMW 430I 2025
SERVICE BRAKES
Delivery Stop – Brake Fluid Expansion Tank
MC-11016435-0001.pdf
SIB 61 03 25 (2025-03-05)
BMW I4 2023,2024
BMW I7 2023
BMW IX 2023
ELECTRICAL SYSTEM
This is an informational bulletin regarding Plug & Charge function complaint diagnosis. Possible customer complaints: Plug & Charge menu does not appear in the vehicle, function not available Problems with the configuration, for example: Contracts cannot be installed Fault / problems when attempting charging with Plug & Charge Plug & Charge contract disappeared Plug & Charge payment method expired
MC-11015537-0001.pdf
SIB 06 14 25 (2025-03-05)
BMW X3 2025
BMW X4 2025
UNKNOWN OR OTHER
Windshield Cleaning Container Return
MC-11015858-0001.pdf
SIB 52 03 25 (2025-02-28)
BMW 230I 2025
BMW 330I 2025
BMW 430I 2025
ELECTRICAL SYSTEM
The drivers seat heater doesnt work after the installation of a replacement seat harness part number (P/N)52 10 7 414 701.
MC-11014658-0001.pdf
SIB 52 05 25 (2025-02-28)
BMW 230I 2025
BMW 330I 2025
BMW 530I 2025
BMW 840I 2025
BMW X1 2025
BMW X3 2025
BMW X4 2025
BMW X5 2025
BMW X6 2025
BMW X7 2025
BMW XM 2024
ELECTRICAL SYSTEM
The customer states: The drivers seat will not return to its last saved position. No seat memory. The heated seats settings in the menu are missing/different than in their previous BMW vehicle. They canno longer select, under the climate rules, at what temperature Fahrenheit the heated seats willautomatically turn on. Certain other apps and functions are not available The drivers seat moves to an unknown memory position
MC-11014660-0001.pdf
SIB 64 01 25 (2025-02-28)
BMW 330I 2024
BMW X3 2024
BMW X4 2024
BMW Z4 2023
UNKNOWN OR OTHER
The customer may hear an intermittent humming or foghorn type sound in vehicle. It sounds like a lowhum that last for only a few seconds. This can occur with the engine operating or may be heard for up to one hour after engine shut down.
MC-11014665-0001.pdf
SIB 64 02 25 (2025-02-28)
BMW I4 2024
STRUCTURE: BODY
The customer states that when the AC system is on, there is a vibrating noise heard from within theinstrument panel. The noise is intermittent. The noise can be heard better outside the vehicle with the hood open.
MC-11014666-0001.pdf
SIB 65 03 25 (2025-02-28)
BMW X1 2023
ELECTRICAL SYSTEM
The customer states that the air bag warning lamp is illuminated. A fault is stored in the airbag control module ACSM6 for either of the front seats: 930982 – side air bag PASSENGER : resistance too high 93097C – side air bag DRIVER : resistance too high
MC-11014668-0001.pdf
SIB 62 02 25 (2025-02-26)
BMW 740I 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
UNKNOWN OR OTHER
For certain model vehicles with the S68T engine, the Condition Based Service (CBS) data may show sparkplug replacement is due at a considerably earlier interval than specified in the Service and WarrantyInformational Booklet.
MC-11014663-0001.pdf
SIB 61 30 23 (2025-02-25)
BMW 7 2023
BMW 740I 2023
BMW I7 2023
ELECTRICAL SYSTEM
In the event of a voltage drop, comfort functions of the interaction bar may fail and not respond.
MC-11014515-0001.pdf
SIB 06 09 25 (2025-02-25)
BMW 740I 2024
EXTERIOR LIGHTING
LED Upper Headlights Return
MC-11014695-0001.pdf
SIB 16 01 25 (2025-02-22)
BMW 330I 2024,2025
BMW 430I 2024,2025
FUEL/PROPULSION SYSTEM
Update – Delivery Stop: Integrated Fuel Module
MC-11014964-0001.pdf
SIB 51 04 25 (2025-02-22)
BMW 530I 2025
BMW 740I 2025
BMW X1 2025
BMW X2 2025
BMW X3 2025
STRUCTURE: BODY
BMW Service Action – Tailgate Lock B51 04 25
MC-11014969-0001.pdf
SIB 18 01 25 (2025-02-21)
BMW X1 2025
BMW X2 2025
POWER TRAIN
The rear silencer is discolored.
MC-11014423-0001.pdf
SIB 28 01 25 (2025-02-21)
BMW X1 2024
BMW X2 2024
POWER TRAIN
A Check Control message (CCM) displays for Transmission oil service required (ID 2120). This warning will trigger based on the following that applies: From 60,000 miles (~95,000 km) to 78,000 miles (~125,000 km), or After six (6) years: The six years time interval is determined the production date of the vehicle. It is notbased on the day/date of the first registration, or the completion date of the pre-delivery check (PDI). If the vehicle is driven more than approx. 1900 miles (~3,000 km) after the first CCM, then a secondmessage will be display for Transmission fault! (ID 368).
MC-11014433-0001.pdf
SIB 16 01 25 (2025-02-21)
BMW 330I 2024,2025
BMW 430I 2024,2025
FUEL/PROPULSION SYSTEM
B16 01 25 Integrated Fuel Module Delivery Stop Software Update
MC-11014965-0001.pdf
RECALL 25V109000 (2025-02-21)
Affecting 114 total vehicles
BMW X3 2025
ELECTRICAL SYSTEM: 12V/24V/48V BATTERY: CABLES
BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 xDrive vehicles. The connection between the positive battery cable and the starter-generator may have been improperly tightened and overheat.
RCRIT-25V109-3829.pdf
SIB 11 07 23 (2025-02-20)
BMW 7 2023
BMW 740I 2023,2024
BMW ALPINA XB7 2023
BMW X5 2023,2024
BMW X6 2023,2024
BMW X7 2023,2024
ENGINE
The return springs on the exhaust camshaft followers (switchable rocker arm) may break.
MC-11014420-0001.pdf
SIB 51 10 22 (2025-02-20)
BMW IX 2021,2022
STRUCTURE: BODY
Groaning noise in the front parcel shelf of the luggage compartment area. The noise is mostly head when the vehicle interior is cold.
MC-11014510-0001.pdf
SIB 51 31 24 (2025-02-20)
BMW 530I 2023,2024,2025
UNKNOWN OR OTHER
The clear coat on the carbon fiber MPerformance rear spoiler is delaminating.
MC-11014657-0001.pdf
RECALL 25V106000 (2025-02-20)
Affecting 40736 total vehicles
BMW X3 2022,2023,2024
LATCHES/LOCKS/LINKAGES: DOORS: LOCK
BMW of North America, LLC (BMW) is recalling certain 2022-2024 X3 sDrive30i and X3 xDrive30i vehicles. The second-row seat side door locking modules may not function properly and allow the doors to be unlocked with a single motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, “Door Locks and Door Retention Components.”
RCRIT-25V106-1058.pdf
RCRIT-25V106-9664.pdf
SIB 51 08 24 (2025-02-14)
BMW 530I 2024
BMW 740I 2024
BMW IX 2024
BMW X1 2024
BMW X2 2024
BMW X3 2025
BMW X5 2025
BMW X6 2025
BMW X7 2025
BMW XM 2024
UNKNOWN OR OTHER
The Augmented Reality Camera (ARCAM) shows up blurry when activated.
MC-11014509-0001.pdf
SIB 11 11 24 (2025-02-12)
BMW M8 2024
ENGINE
One of the six engine oil pump mounting screws may not have been tightened with the correct torque.
MC-11014421-0001.pdf
SIB 52 02 25 (2025-02-12)
BMW 530I 2024
BMW 740I 2024
ELECTRICAL SYSTEM
The electric front seat adjustment does not work. The problem can occur to the left, as well as the right seat.
MC-11014511-0001.pdf
SIB 51 04 25 (2025-02-07)
BMW 530I 2025
BMW 740I 2025
BMW X1 2025
BMW X2 2025
BMW X3 2025
STRUCTURE: BODY
Due to changes in the opening mechanism ofthe trunk/tailgate latch, it is possible that thetrunk/tailgate may not completely lock afterclosing it.
MC-11014036-0001.pdf
SIB 52 01 25 (2025-02-04)
BMW 740I 2023
ELECTRICAL SYSTEM
The customer sees various check control warnings of ‘Drive Fault’, along with windows, doors, and seatsthat do not function. There may be restraint system check control warnings. The entire K-CAN9 / Body3 CAN bus may not communicate. Various fault memory entries for the above-mentioned components may be stored: 930D86 – Function restraint system driver restricted. 930D87 – Function front passenger restraint system restricted. C9544D, C9544F – Message Missing C95452, C95454 – Signal invalid 035BF4, 035BFB, 035BFC, 035BFD – Communication via Body3_CAN corrupt. CD052C, E3852C, E4852C, E3452C, E4452C, DF852C, DFC52C, DDC52C, DF452C, E6052C, E5852C- BODY3-CAN Control Module Bus OFF 802A00, 802E00, 802C00, 803000 – Functions seat heating not available 803003, 802C03, 802E03, 802A03 – Functions seat adjustment limited
MC-11014039-0001.pdf
SIB 51 46 16 (2025-02-03)
BMW 228I 2020,2021,2022
BMW 230I 2023,2024
BMW 328I 2013,2014,2015,2016
BMW 330E 2021,2022,2023
BMW 330I 2017,2018,2019,2020,2021,2022,2023,2024
BMW 335I 2013,2014,2015,2016
BMW 340I 2017,2018,2019,2020
BMW 428I 2015,2016
BMW 430I 2017,2018,2019,2020,2021,2022,2023,2024
BMW 435I 2015,2016
BMW 440I 2017,2018,2019,2020
BMW 5-SERIES GRAN TURISMO 2017
BMW 530E 2018,2019,2020,2021,2022,2023
BMW 530I 2017,2018,2019,2020,2021,2022,2023,2024
BMW 540D 2018,2019,2020
BMW 540I 2017,2018,2019,2020,2021,2022,2023
BMW 640I 2018,2019,2020
BMW 740E 2017,2018,2019
BMW 740I 2017,2018,2019,2020,2021,2022,2023,2024
BMW 740LI 2016,2017
BMW 745E 2020,2021,2022
BMW 750I 2018,2019
BMW 750LI 2016,2017,2018,2019,2020,2021,2022
BMW 760I 2023
BMW 840I 2020,2021,2022,2024
BMW ALPINA XB7 2021,2022,2023
BMW B7 ALPINA 2018,2019,2020,2021
BMW I4 2022,2023
BMW I7 2023
BMW IX 2022,2023
BMW M2 2016,2017,2018,2019,2020,2021,2022
BMW M235I 2020,2021,2022
BMW M3 2015,2016,2017,2018,2021,2022,2023
BMW M340I 2020,2021,2022,2023
BMW M4 2015,2016,2017,2018,2019,2020,2021,2022,2023
BMW M4 GT4 2023
BMW M440I 2021,2022
BMW M5 2018,2019,2020,2021,2022
BMW M550I 2017,2018,2019,2020,2021,2022,2023
BMW M760I 2017,2018,2019,2020,2021,2022
BMW M760LI 2021,2022
BMW M8 2020,2021,2022,2023
BMW M8 GRAN COUPE 2020
BMW M850I 2019,2020,2021,2022
BMW M850XI 2019
BMW X1 2016,2017,2018,2019,2020,2021,2022,2023,2024
BMW X1 SAV 2016,2017
BMW X2 2018,2019,2020,2021,2022,2024
BMW X3 2018,2019,2020,2021,2022,2023,2024
BMW X4 2019,2020,2021,2022,2023,2024
BMW X5 2015,2016,2017,2019,2020,2021,2022,2023,2024
BMW X5 M 2018
BMW X6 2020,2021,2022,2024
BMW X6 M 2015,2016,2017,2018,2019,2020
BMW X7 2019,2020,2021,2022,2023,2024
BMW XM 2023
(plus 1 other model)
STRUCTURE: BODY
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
MC-11014038-0001.pdf
SIB 64 07 23 (2025-02-03)
BMW 430I 2023
BMW I4 2022,2023
ELECTRICAL SYSTEM
DELIVERY STOP: EKK (eKMV) Circuit Board
MC-11014040-0001.pdf
SIB 06 07 25 (2025-01-31)
BMW 330I 2024
EXTERIOR LIGHTING
Headlight Return
MC-11013442-0001.pdf
SIB 12 06 24 (2025-01-29)
BMW 330I 2024
BMW 740I 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
ENGINE
BMW AG has decided on a service campaign for certain vehicles from the G0x, G12 and G20 series. Please have the starter motor checked and, if necessary, replaced in the vehicles concerned (according to the vehicle identification number selection) if possible before vehicle delivery. If vehicles have already been delivered, please have the measure carried out the next time the vehicles enter the workshop. A bolting fault on the long bolt screws can cause the magnets in the starter motor to twist. As a result, the power of the starter motor decreases. As a result, the engine does not start.
MC-11013434-0001.pdf
SIB 34 01 24 (2025-01-29)
BMW 530I 2024
BMW 740I 2024
BMW I5 2024
BMW I7 2024
BMW IX 2024
BMW X1 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
ELECTRICAL SYSTEM
After replacement of the Integrated Braking system (IB)/Power Brake the total distance covered might be lower than when handed over to the workshop for the repair.
MC-11013438-0001.pdf
SIB 06 05 25 (2025-01-27)
BMW X3 2024
BMW X4 2024
UNKNOWN OR OTHER
Door Trim Return
MC-11013444-0001.pdf
SIB 11 10 24 (2025-01-24)
BMW 740I 2023,2024
BMW X5 2023,2024
BMW X6 2023,2024
BMW X7 2023,2024
ENGINE
The engine oil pump mounting screws may not have been tightened with the correct torque.
MC-11013114-0001.pdf
SIB 35 01 23 (2025-01-24)
BMW 740I 2024
BMW I7 2024
BMW IX 2024
SERVICE BRAKES
When the brake pedal is pressed/ released, a creaking noise may be heard from the pedal area for the Integrated Brake System (IB). This noise may be present with the vehicle stationary and the engine running.
MC-11013115-0001.pdf
SIB 06 04 25 (2025-01-22)
BMW 840I 2024
SEATS
FITTINGS RETURN
MC-11013098-0001.pdf
SIB 01 16 24 (2025-01-16)
BMW 330I 2018,2019
BMW 530I 2018,2019
BMW 650I 2018
BMW 750I 2018,2019,2020
BMW 850I 2019
BMW X2 2018,2019
BMW X5 2019,2020
BMW X6 2020
BMW X7 2019,2020
ELECTRICAL SYSTEM
The Telematics Control Units (TCU) Internal Emergency (Backup) Battery for defects in materials and/or workmanship has been extended to 6 years without mileage limitation, as determined from the vehicles original first in-service / delivery date. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty.
MC-11013037-0001.pdf
SIB 11 09 24 (2025-01-15)
BMW 330I 2024,2025
BMW 530I 2024,2025
BMW X5 2024,2025
BMW X7 2024,2025
POWER TRAIN
During manufacturing, the dual-mass flywheel has not been sufficiently greased. The insufficient grease may result in acoustic abnormalities and vibrations in the vehicle’s powertrain.
MC-11013112-0001.pdf
SIB 34 09 21 (2025-01-14)
BMW M2 2016,2017,2018,2019,2020,2021,2022
BMW M3 2015,2016,2017,2018,2021,2022
BMW M4 2015,2016,2017,2018,2019,2020,2021,2022
BMW M5 2016,2018,2019,2020
SERVICE BRAKES
A turbine-like noise can be heard from the rear axle while deceleration during the first 300 miles of operation when braking from low speed.
MC-11013041-0001.pdf
SIB 65 02 25 (2025-01-14)
BMW 330I 2025
BMW 430I 2025
BMW 530I 2025
BMW 740I 2025
BMW IX 2025
BMW X5 2025
BMW X6 2025
BMW X7 2025
UNKNOWN OR OTHER
If the Head-Up Display (HUD) is deactivated when Navigation View is selected, upon reactivation the Head-Up Display (HUD) will revert to the Standard View. This is most noticeable when the Head-Up Display (HUD) deactivates for automatic mandatory reasons, such as rear camera activation or emergency call activation.
MC-11013062-0001.pdf
SIB 51 02 25 (2025-01-13)
BMW IX 2025
STRUCTURE: BODY
While driving on a smooth and/or uneven road, a clicking sound is heard from the drivers footwell area.
MC-11013044-0001.pdf
SIB 54 03 24 (2025-01-13)
BMW Z4 2019,2020,2021,2022,2023
STRUCTURE: BODY
The convertible top does not open or close.
MC-11013048-0001.pdf
SIB 64 08 24 (2025-01-10)
BMW XM 2023,2024
ELECTRICAL SYSTEM
EMISSIONS RECALL 24E-A03: HEATING AND AIR CONDITIONING SYSTEM
MC-11013057-0001.pdf
SIB 32 01 25 (2025-01-10)
BMW 530I 2024
BMW 740I 2024
BMW IX 2024
BMW X3 2024
STEERING
Rumbling, groaning type noises from the EPS when the steering wheel is at the end stops.
MC-11013039-0001.pdf
SIB 63 03 24 (2025-01-10)
BMW X1 2024
BMW X2 2024
UNKNOWN OR OTHER
The welcome light image displayed from the exterior mirror assembly is distorted.
MC-11013052-0001.pdf
SIB 63 04 24 (2025-01-10)
BMW 530I 2025
BMW 740I 2025
BMW X1 2025
BMW X2 2025
BMW X3 2025
ELECTRICAL SYSTEM
After the vehicle has been programmed with either RSU (Remote Software Update) or ISTA (I-Level 24-07-5xx), the ambient light on the door panel speakers will only illuminate in white.
MC-11013053-0001.pdf
SIB 37 01 25 (2025-01-10)
BMW 530I 2024
BMW 840I 2024
SUSPENSION
DELIVERY STOP: SUSPENSION STRUT HOLDER
MC-11013116-0001.pdf
SIB 51 22 24 (2025-01-10)
BMW 330I 2024
BMW 530I 2024
BMW X1 2024
BMW X2 2024
BMW X3 2024
BMW X4 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
UNKNOWN OR OTHER
On the main door seal, detachment behavior can be detected in the sealing joint area. Overtime, the sealing material continues to detach more and more, which can cause the seal to dangle and become visible to the customer.
MC-11013119-0001.pdf
SIB 61 11 24 (2025-01-07)
BMW 530I 2024
BMW 7 2023
BMW 740I 2023,2024
BMW 750E 2024
BMW 760I 2023,2024
BMW IX 2021,2022,2023,2024
BMW X1 2023,2024
BMW X2 2018,2019,2020,2021,2022,2023,2024
BMW X5 2019,2020,2021,2022,2023,2024
BMW X5 HYBRID 2021,2022
BMW X6 2020,2021,2022,2023,2024
BMW X7 2019,2020,2021,2022,2023,2024
BMW XM 2023,2024
(plus 1 other model)
ELECTRICAL SYSTEM
After performing a BMW Remote Software Upgrade (RSU), the functionality of the Comfort Access and Passive Go/Exit features may be reduced.
MC-11013050-0001.pdf
SIB 51 19 24 (2025-01-07)
BMW 530I 2024
BMW 740I 2024
VISIBILITY/WIPER
There is a matte veil or milky stain on the exterior mirror glass.
MC-11013046-0001.pdf
SIB 65 01 22 (2025-01-06)
BMW X3 2018,2019,2020,2021,2022,2023
BMW X4 2018,2019,2020,2021,2022,2023
AIR BAGS
The limited warranty for the Knee Air Bag wire harness repair cable procedure for defects in materials and / or workmanship has been extended to 10 years / 120,000 miles as determined from the original first in-service / delivery date.
MC-11013058-0001.pdf
SIB 61 01 24 (2025-01-06)
BMW 5 SERIES 2023,9999
BMW 530I 2023,2024
BMW 7 2023
BMW 7 SERIES 9999
BMW 740I 2023,2024
BMW I5 2024,2025
BMW I7 2023,2024
UNKNOWN OR OTHER
When driving over rough surfaces, a low-frequency rattling noise can be heard inside the vehicle’s cabin. The noise typically sounds as though it is coming from the front right footwell area.
MC-11013049-0001.pdf
SIB 06 01 25 (2025-01-04)
BMW 740I 2024
STEERING
SWIVEL JOINT RETURN
MC-11013107-0001.pdf
SIB 65 02 22 (2025-01-02)
BMW ALPINA XB7 2022,2023
BMW B7 ALPINA 2021
BMW X5 2019,2020,2021,2022,2023
BMW X6 2019,2020,2021,2022
BMW X6 M 2020
BMW X7 2019,2020,2021,2022,2023
AIR BAGS
The limited warranty for the Knee Air Bag wire harness repair cable procedure for defects in materials and/or workmanship has been extended to 10 years / 120,000 miles as determined from the original first in-service / deliver date.
MC-11013061-0001.pdf
SIB 01 18 24 (2024-12-31)
BMW 330I 2018,2019,2020
BMW 430I 2019,2020
BMW 530I 2018,2019
BMW 740I 2019
BMW X2 2018,2019,2020
ELECTRICAL SYSTEM
The Telematics Control Units (TCU) Internal Emergency (Backup) Battery for defects in materials and/or workmanship has been extended to 6 years without mileage limitation, as determined from the vehicles original first in-service / delivery date.
MC-11012111-0001.pdf
SIB 06 89 24 (2024-12-31)
BMW X5 2024
BMW X6 2024
BMW X7 2024
UNKNOWN OR OTHER
Vinyl Rear Panel
MC-11012323-0001.pdf
SIB 65 40 24 (2024-12-27)
BMW X1 2024
BMW X2 2024
BMW X3 2025
ELECTRICAL SYSTEM
Customers may report various issues in the vehicle, to include: Bluetooth Malfunctions Head Unit Performance Telephony Malfunctions
MC-11012101-0001.pdf
SIB 28 02 24 (2024-12-20)
BMW X1 2022,2023,2024
BMW X2 2023,2024
POWER TRAIN
Micro-movements combined with frictional corrosion can increase wear on the longitudinal splined connection between the double clutch transmission (DCT) and the transfer box.
MC-11012087-0001.pdf
SIB 61 30 24 (2024-12-19)
BMW X1 2022,2023,2024
BMW X2 2022,2023,2024
ELECTRICAL SYSTEM
Due to a software error in the Basic Central Platform (BCP), Remote Software Upgrade (RSU) is no longerpossible.
MC-11012092-0001.pdf
SIB 61 06 15 (2024-12-18)
BMW 228I 2014,2015,2016
BMW 230I 2017,2018,2019,2020,2021,2024
BMW 330E 2021
BMW 330I 2019,2020,2021,2024
BMW 430I 2021,2024
BMW M235I 2014,2015,2016
BMW M240I 2017,2018,2019,2020,2021
BMW M340I 2020,2021
BMW M440I 2021
BMW R 1200 GS ADVENTURE 2017
STRUCTURE: BODY
Rattling noises heard from vicinity of glove box.
MC-11012091-0001.pdf
SIB 65 33 24 (2024-12-13)
BMW IX 2023,2024,2025
LANE DEPARTURE: ASSIST
Customer may complain that the hands-free option with SA 5AX Highway Assistant can no longer beactivated.
MC-11012095-0001.pdf
SIB 65 36 24 (2024-12-13)
BMW 530I 2024
BMW 740I 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
ELECTRICAL SYSTEM
Customers may report issue with Personal eSIM operation, to include: Personal eSIM does not finish the set-up process in the vehicle Telephone function via eSIM is not possible WiFi Hotspot function cannot be used Streaming video service via the BMW Theater Screen is not possible
MC-11012097-0001.pdf
SIB 65 37 24 (2024-12-13)
BMW IX 2024
ELECTRICAL SYSTEM
Customers may report issue with Personal eSIM operation, to include: Personal eSIM does not finish the set-up process in the vehicle Telephone function via eSIM is not possible WiFi Hotspot function cannot be used Streaming video service via the BMW Theater Screen is not possible
MC-11012098-0001.pdf
SIB 65 38 24 (2024-12-13)
BMW 330I 2024
BMW 430I 2024
BMW 530I 2024
BMW 740I 2024
BMW X5 2024
BMW X6 2024
BMW X7 2024
BMW XM 2024
ELECTRICAL SYSTEM
Customers may report issue with Personal eSIM operation, to include: Personal eSIM does not finish the set-up process in the vehicle Telephone function via eSIM is not possible WiFi Hotspot function cannot be used Streaming video service via the BMW Theater Screen is not possible
MC-11012099-0001.pdf
SIB 65 39 24 (2024-12-13)
BMW IX 2024
ELECTRICAL SYSTEM
Customers may report issue with Personal eSIM operation, to include: Personal eSIM does not finish the set-up process in the vehicle Telephone function via eSIM is not possible WiFi Hotspot function cannot be used Streaming video service via the BMW Theater Screen is not possible
MC-11012100-0001.pdf
SIB 06 87 24 (2024-12-13)
BMW 530I 2024
SUSPENSION
Spring Strut Return
MC-11012325-0001.pdf
SIB 01 08 21 (2024-12-11)
BMW M5 2020
BMW M8 2020
BMW X3 2020
BMW X4 2020
BMW X5 2020
BMW X6 2020
ENGINE
The NVLD limited emission related warranty for defects in materials or workmanship has been extended to 15 years/150,000 miles as determined from the original in-service date
MC-11012066-0001.pdf
SIB 01 09 21 (2024-12-11)
BMW 530I 2017,2018,2019,2020
BMW X3 2017,2018,2019,2020
BMW X4 2017,2018,2019,2020
ENGINE
The NVLD limited emission related warranty for defects in materials or workmanship has been extended to 15 years/150,000 miles as determined from the original in-service date.
MC-11012067-0001.pdf
SIB 01 15 24 (2024-12-11)
BMW 530I 2017,2018,2019,2020
BMW X3 2018,2019,2020
BMW X4 2018,2019,2020
ENGINE
the NVLD limited emissionrelated warranty for defects in materials or workmanship has been extended to 15 years/150,000 miles as determined from the original in-service date.
MC-11012074-0001.pdf
SIB 12 05 23 (2024-12-10)
BMW I4 2022,2023,2024
BMW I5 2024
BMW I7 2023,2024
BMW IX 2021,2022,2023,2024
ELECTRICAL SYSTEM
The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster. In addition, the following fault memory entries are saved in the CCU (Combined Charging Unit) 0317F2 – High-voltage system, insulation fault detected: when switch contactors are closed. 0317F1 – High-voltage system, insulation resistance below warning threshold: when switch contactors are closed. The fault memory entries (isolation faults) can occur both individually and in combination and must be traced back to the eDrive motor based on the ISTA test procedure. If ISTA test procedure lists possible cause of fault as; A metal chip is found behind the brush module (between the brush module and the end shield of the electrical machine). Repair required. Refer to service solution no. 20000794435083 in Aftersales Information Research (AIR). Follow information in the Procedure section below.
MC-11012080-0001.pdf
SIB 64 11 24 (2024-12-09)
BMW I4 2023,2024
BMW I5 2024
BMW I7 2023,2024
ELECTRICAL SYSTEM
Quality checks have determined that the coolant changeover valve may develop a coolant leak undervery low outside temperatures (significantly lower than 32º F (0 C)).
MC-11012093-0001.pdf
SIB 64 13 24 (2024-12-09)
BMW IX 2023,2024
ENGINE
Quality checks have determined that the coolant changeover valve may develop a coolant leak under verylow outside temperatures (significantly lower than 32º F (0 C)).
MC-11012094-0001.pdf
Last edited by analogue; Today at 05:39 PM..